flat tire Ram 3500 2016 Service Manual

WARNING!(Continued)
•If working on or near a roadway, be extremely
careful of motor traffic.
• To assure that spare tires, flat or inflated, are
securely stowed, spares must be stowed with the
valve stem facing the ground.
CAUTION!
Do not attempt to raise the vehicle by jacking on
locations other than those indicated in the Jacking
Instructions for this vehicle.
Jack Warning Label
Lug Wrench Adaptor Shown In Jack And Tools
Assembly
6
WHAT TO DO IN EMERGENCIES 759

5. Remove the wheel nuts and pull the wheel off. Onsingle rear-wheel (SRW) trucks, install the spare wheel
and wheel nuts with the cone shaped end of the wheel
nuts toward the wheel. On 3500 dual rear-wheel
models (DRW) trucks, if the outer tire is being re-
placed then leave the inner wheel on the vehicle. If the
inner wheel is being replaced remove the outer wheel
and replace the inner wheel. The wheel nuts are a
two-piece assembly with a flat face. Lightly tighten the
wheel nuts. To avoid the risk of forcing the vehicle off
the jack, do not fully tighten the wheel nuts until the
vehicle has been lowered.
Rear Inner Wheel Proper Placement (Dual Rear Wheel
Equipped)
6
WHAT TO DO IN EMERGENCIES 763

9. Adjust the tire pressure when possible.
NOTE:Do not oil wheel studs. For chrome wheels, do
not substitute with chrome plated wheel nuts.
To Stow The Flat Or Spare
NOTE: Have the flat tire repaired or replaced immedi-
ately.
WARNING!
A loose tire thrown forward in a collision or hard
stop could injure the occupants in the vehicle. Have
the deflated (flat) tire repaired or replaced immedi-
ately.
1. Turn the wheel so that the valve stem is facing the ground and toward the rear of the vehicle for conve-
nience in checking the spare tire inflation. Slide the
wheel retainer through the center of the wheel. 2. Lift the spare tire with one hand to give clearance to
tilt the retainer at the end of the cable and position it
properly across the wheel opening.
Reinstalling The Retainer
6
WHAT TO DO IN EMERGENCIES 765

flat blade on the end of the lug wrench to pull the caps
off. The wheel skin can now be removed.
CAUTION!
•Use a pulling motion to remove the hub cap. Do not
use a twisting motion when removing the hub cap,
damage to the hub cap; finish may occur.
• The rear hub caps on the dual rear wheel has two
pull off notches. Make sure that the hook of the
jack handle driver is located squarely in the cap
notch before attempting to pull off.
You must use the flat end of the lug wrench to pull off the
wheel skins. Locate the hub cap pull notches (2 notches
on each cap). Insert the flat tip completely and using a
back and forth motion, loosen the wheel skin. Repeat this
procedure around the tire until the skin pops off. Replace the wheel skins first using a rubber mallet. When
replacing the hub caps, tilt the cap retainer over the lug
nut bolt circle and strike the high side down with a
rubber mallet. Be sure that the hub caps and wheel skins
are firmly seated around the wheel.
HOISTING
A conventional floor jack may be used at the jacking
locations. Refer to the graphics that show jacking loca-
tions. However, a floor jack or frame hoist must never be
used on any other parts of the underbody.
CAUTION!
Never use a floor jack directly under the differential
housing of a loaded truck or damage to your vehicle
may result.
770 WHAT TO DO IN EMERGENCIES

Temperature Grades
The temperature grades are A (the highest), B, and C,
representing the tire’s resistance to the generation of heat
and its ability to dissipate heat, when tested under
controlled conditions on a specified indoor laboratory
test wheel. Sustained high temperature can cause the
material of the tire to degenerate and reduce tire life, and
excessive temperature can lead to sudden tire failure. The
grade C corresponds to a level of performance, which all
passenger vehicle tires must meet under the Federal
Motor Vehicle Safety Standard No. 109. Grades B and A
represent higher levels of performance on the laboratory
test wheel, than the minimum required by law.
WARNING!
The temperature grade for this tire is established for
a tire that is properly inflated and not overloaded.
Excessive speed, under-inflation, or excessive load-
ing, either separately or in combination, can cause
heat buildup and possible tire failure.
9
IF YOU NEED CONSUMER ASSISTANCE 893

Flat Tire Stowage..................... .745, 765
Flexible Fuel Vehicles Cruising Range ........................ .683
Engine Oil ........................... .682
Fuel Requirements ...................681, 682
Maintenance .......................... .684
Replacement Parts ...................... .683
Starting ............................. .683
Flooded Engine Starting ....................480
Fluid, Brake ............................ .870
Fluid Capacities ......................... .864
Fluid Leaks ............................ .122
Fluid Level Checks Brake ............................... .826
Power Steering ........................ .615
Fluids, Lubricants And Genuine Parts ...........866
Fog Lights ....................... .176, 317, 856
Fold Flat Load Floor ...................... .249
Four-Way Hazard Flasher ...................727 Four Wheel Drive
........................ .522
Freeing A Stuck Vehicle .....................775
Front Axle (Differential) .....................827
Fuel .................................. .675
Adding ............................. .684
Additives ............................ .679
Clean Air ............................ .677
Ethanol .......................... .677, 681
Filler Cap (Gas Cap) .....................686
Gasoline ............................. .675
Light ............................... .314
Materials Added ....................... .679
Methanol ............................ .677
Octane Rating ..................... .675, 866
Requirements ...................... .675, 864
Tank Capacity ......................... .864
Fuel, Flexible ........................... .681
Fuses ................................. .841
902 INDEX

Hood Release........................... .168
Hub Caps .............................. .769
Ignition .................................16
Key .............................. .12, 16
Ignition Key Removal .......................16
Illuminated Entry ..........................24
Immobilizer (Sentry Key) ....................19
Inflation Pressure Tires .....................660
Information Center, Vehicle ...............331, 351
Inside Rearview Mirror ..............130, 131, 138
Instrument Cluster ..................289, 300, 326
Instrument Panel And Controls ...............288
Instrument Panel Lens Cleaning ...............839
Integrated Trailer Brake Controls ..............703
Interior Appearance Care ....................837
Interior Lights .......................... .177
Intermittent Wipers (Delay Wipers) .............183
Introduction ..............................4 Inverter Outlet (115V)
..................... .235
Jack Location ........................ .731, 750
Jump Starting ........................... .771
Key Fob Programming Additional Key Fobs ...........21
Programming Additional Transmitters .........21
Key-In Reminder ..........................18
Keyless Enter-N-Go .....................43, 478
Lock The Vehicle’s Doors ..............386, 406
Passive Entry ...........................43
Passive Entry Programming ..........43, 386, 406
Keyless Entry System .......................25
Key, Replacement ..........................20
Keys ...................................12
Key, Sentry (Immobilizer) ....................19
Lane Change And Turn Signals ...............181
904 INDEX

Remote...............................34
Starting Procedures (Gas Engines) .............477
Steering Power ........................... .613, 615
Wheel, Heated ........................ .187
Wheel, Tilt ........................... .186
Steering Wheel Audio Controls ...............417
Steering Wheel Mounted Sound System Controls . . .417
Storage Compartment, Center Seat .............242
Storage, Vehicle ...................... .441, 851
Storing Your Vehicle ...................... .851
Sun Roof .............................. .226
Supplemental Restraint System - Air Bag .........71
Supplemental Tire Pressure Information .........660
Suspension, Air ...................... .545, 558
Sway Control, Trailer ...................... .632
Synthetic Engine Oil ...................... .802
System, Remote Starting .....................34 Tailgate
............................... .271
Temperature Control, Automatic (ATC) ..........439
Tilt Down .............................. .148
Up ................................ .148
Tilt Steering Column ...................... .186
Tip Start ............................... .478
Tire And Loading Information Placard . . . .643, 644, 660
Tire Markings ........................... .636
Tires ....................... .122, 648, 654, 891
Aging (Life Of Tires) .....................658
Air Pressure .......................... .648
Chains .............................. .660
Compact Spare ........................ .655
Dual ............................ .664, 729
General Information ..................648, 654
High Speed .......................... .651
Inflation Pressures ...................... .649
Life Of Tires .......................... .658
912 INDEX